Page 1 of 2

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA031  
    Pre-opening
    Original Inspection
X Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  MAYBERRY JUNCTION RESTAURANT Address  390 N LOCUST
Owner or Operator   KIOUSIS, ARLEEN City   MANTENO Zip Code   60950
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
X
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
X
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
X
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
X
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
 
1
 Thermometers provided and conspicuous
37
  
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
  
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
  
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
  
5
 Toxic items properly stored, labeled and used
*12
X
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
  
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
  
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes     No X Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   chlorine 200 ppm                   Dishwasher Temperature   chlorine 200 °F or label
Food Temperatures:   turkey 140, sausage 34, chicken 34, cheese 38, soup 170, dressing 39, bacon 75, eggs 59-65
 
General Comments
This facility has made many improvements in the past 48 hours. There are still many food handling issues that need to be worked on. Please make sure that you look at all of your produce to make sure it is not moldy, make sure under no circumstances the cooks leave eggs or bacon out so that it gets out of temperature and finally please go over hand washing practices with employees (handouts given)

A follow up will occur again in 15 days to follow up on food handling practices and temperatures 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  03/29/2007 Time In  8:30 AM Time Out  10:30 AM Sanitation Score  80 (100 Minus Demerits)
By  Janet Weldon (Sanitarian) Adjusted Score  80  
 
Page 2 of 2

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA031  
    Pre-opening
    Original Inspection
X Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  MAYBERRY JUNCTION RESTAURANT Address  390 N LOCUST
Owner or Operator   KIOUSIS, ARLEEN City   MANTENO Zip Code   60950
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*1  Observed the following foods to be unwholesome/spoiled 1. Pepper in walk in cooler *Provide for all foods to be wholesome and free from spoilage (750.100) Immediate/Onsite
*3  Observed the following potentially hazardous foods to be held at improper temperatures: 1. Eggs 59-64 2. bacon 75 *FOODS CANNOT BE LEFT OUT NO MATTER HOW BUSY. FOODS MUST KEEP TEMPERATURES OF 41 OR BELOW IF COLD AND 140 OR ABOVE IF HOT NO EXCEPTIONS (750.140) Immediate/Onsite
*12  Observed an employee to touch his hat and go back to food preparations *Provide for hands to be properly washed as often as necessary to keep them clean and free of contamination (750.880) Immediate/Onsite
21  Observed wiping cloth(s) to be improperly stored: *Provide for all wiping cloths to be stored completely submerged in an approved sanitizer solution while not being used (750.810) Next Inspection
22  Observed the inside of the lid container to be in need of cleaning *Please clean (750.800) Next Inspection
23  Observed the inside/outside and gaskets on the prep cooler with roll top to be in need of cleaning *please clean (750.800) Next Inspection
36  Observed floors in the walk in cooler to be in need of cleaning *Please clean (750.1220) Next Inspection
     
     
     
     
     
     
     
     
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  03/29/2007 Time In  8:30 AM Time Out  10:30 AM Sanitation Score  80 (100 Minus Demerits)
By  Janet Weldon (Sanitarian) Adjusted Score  80